Scott Essential Electronic Hard Roll Towel Dispenser
Modèle: 48860
1. Introduction
The Scott Essential Electronic Hard Roll Towel Dispenser is designed for efficiency, performance, and value in various environments. This manual provides detailed instructions to ensure proper installation, operation, and maintenance of your dispenser, helping you achieve reliable and consistent towel dispensing.
2. Consignes de sécurité
Please read all safety instructions carefully before installing or operating the dispenser. Failure to follow these instructions may result in product damage or personal injury.
- Ensure the dispenser is securely mounted to a stable surface to prevent it from falling.
- N’exposez pas les composants électroniques à l’eau ou à une humidité excessive.
- Use only the specified type and size of paper towels to prevent jamming.
- Keep hands and fingers clear of the dispensing mechanism during operation.
- Éliminez les piles conformément aux réglementations locales.
- Do not attempt to repair the electronic components yourself. Refer to qualified service personnel.
3. Contenu du colis
Vérifiez que tous les éléments sont présents dans le colis :
- Scott Essential Electronic Hard Roll Towel Dispenser (Model 48860)
- Matériel de montage (vis, chevilles)
- Manuel d'instructions
4. Installation et configuration
4.1 Instructions de montage mural
- Select a suitable wall location, ensuring sufficient clearance for operation and maintenance.
- Hold the dispenser against the wall at the desired height and mark the mounting holes.
- Drill pilot holes at the marked locations. Use appropriate drill bits for your wall material.
- Insert wall anchors (if necessary) into the drilled holes.
- Alignez le distributeur avec les trous et fixez-le au mur à l'aide des vis fournies. Assurez-vous qu'il est bien fixé.
Figure 1 : Côté view of the dispenser, illustrating potential mounting points.
4.2 Installation de la batterie
The dispenser operates on batteries, offering extended life for up to 120,000 dispenses.
- Ouvrez le couvercle du distributeur.
- Localisez le compartiment à piles.
- Insert the required number of D-cell batteries (typically 4) according to the polarity indicators (+/-).
- Fermez soigneusement le compartiment à piles.
5. Fonctionnement
5.1 Loading Paper Towels
This dispenser is designed for 8" diameter x 8" hard roll towels, up to 950 feet in length.
- Ouvrez le couvercle du distributeur.
- Place the new hard roll towel onto the spindle, ensuring it rotates freely.
- Thread the leading edge of the paper towel through the dispensing mechanism as indicated by internal guides.
- Ensure the paper is properly aligned and not creased.
- Fermez bien le couvercle du distributeur.
5.2 Dispensing Towels
The dispenser features an electronic sensor for touchless operation.
- Place your hand beneath the dispensing opening.
- The sensor will detect your hand and automatically dispense a pre-measured length of paper towel.
- Tear the dispensed towel downwards against the cutting edge.
Figure 2 : Face avant view of the dispenser, showing the sensor area and towel exit.
6. Entretien
6.1 Nettoyage
Regular cleaning helps maintain hygiene and dispenser performance.
- Essuyez l'extérieur du distributeur avec un chiffon doux et sec.amp chiffon et savon doux.
- N'utilisez pas de nettoyants ou de solvants abrasifs, car ils pourraient endommager la finition.
- Clean the sensor area periodically to ensure proper detection.
- Veillez à ce qu'aucune humidité ne pénètre dans les composants électroniques.
6.2 Remplacement de la batterie
Replace batteries when the low battery indicator illuminates or dispensing becomes inconsistent.
- Ouvrez le couvercle du distributeur.
- Retirez les vieilles piles du compartiment.
- Insert new D-cell batteries, observing correct polarity.
- Close the battery compartment and dispenser cover.
7. Dépannage
Consultez le tableau ci-dessous pour connaître les problèmes courants et leurs solutions.
| Problème | Cause possible | Solution |
|---|---|---|
| Dispenser not dispensing towels. | No paper roll; Batteries low or dead; Paper jam; Sensor obstructed. | Load new paper roll; Replace batteries; Clear paper jam; Clean sensor area. |
| Towels dispensing inconsistently or too short. | Low batteries; Incorrect paper roll type; Paper not threaded correctly. | Replace batteries; Ensure correct paper type (8" hard roll); Re-thread paper according to instructions. |
| Dispenser making unusual noises. | Paper jam; Mechanical issue. | Clear any paper jam. If noise persists, contact customer support. |
| Cover not closing properly. | Obstruction ; Désalignement. | Check for any obstructions (e.g., paper); Ensure proper alignment before closing. |
8. Spécifications
| Fonctionnalité | Détail |
|---|---|
| Numéro de modèle | 48860 |
| Dimensions (L x l x H) | 12.7" W x 9.572" D x 15.761" H (Product Dimensions: 274.32"L x 8"W) |
| Poids de l'article | 0.01 onces |
| Matériel | Plastique |
| Couleur | Noir |
| Type de montage | Support mural |
| Compatible Paper Towel | 8" diameter x 8" hard roll towels, up to 950 feet |
| Autonomie de la batterie | Up to 5 years or 120,000 dispenses (on one set of batteries) |
9. Garantie et support client
This Scott Essential Electronic Hard Roll Towel Dispenser is backed by a manufacturer's warranty against defects in materials and workmanship. For specific warranty terms and conditions, please refer to the documentation included with your purchase or visit the official Scott website.
If you encounter any issues not covered in this manual or require further assistance, please contact Scott customer support:
- Website: www.scottbrand.com (pour information générale)
- Service client: Refer to the contact information provided on the product packaging or the official brand webConsultez ce site pour obtenir les informations d'assistance les plus récentes.